After initial culture of HHV-7 in PHA-stimulated human cord blood mononuclear cells (HCBMC), six HHV-7 isolates were propagated successfully in an immature continuous T-lymphoblastoid cell line SupT1. All six isolates infected efficiently the SupT1 cells, and the infected cells became grossly enlarged and multinucleated 7-21 days post-infection. Various stages of HHV-7 morphogenesis were detected. Cell-free supernatants from HHV-7-infected SupT1 cells were infectious to HCBMC as well as to SupT1 cells. The HHV-7-infected SupT1 and HCBMC cell lysates contained more infectious virus than the centrifuged cell culture fluid supernates from the same culture. The HHV-7 isolates H7-2, H7-3, JHC, and JB, concentrated 500 times, had average infectivity titers of 10(3.0) TCID50/ml while strains H7-4 and KHR titered approximately 1-2 logs higher. When all six HHV-7 isolates were propagated in SupT1 and culture fluid supernatants were examined 14-21 days post-infection by negative stain electron microscopy they contained an average of 1.9 x 10(9) virus particles/liter. IFA and ELISA, using HHV-7/SupT1 cell lysate as an antigen, seem to correlate well in detecting high and low HHV-7 antibody in sera from chronic fatigue patients and healthy donors as controls. HHV-7 from SupT1 cell culture was free of HHV-6 and other human herpesviruses as tested by PCR, and the HHV-7 PCR signal was still strong when the viral preparation was diluted to 4.82 x 10(2) genome copies. Since HCBMC are expensive to obtain and available in only small amounts, it is difficult to obtain large quantities of HHV-7 antigen. On the other hand, the SupT1 cell is an excellent source to produce consistently sufficient quantities of HHV-7 for purification studies, development of immunodiagnostics, in vivo infectivity studies, evaluation of antiviral drugs, and molecular biological studies.