A method for reclaiming nutrients from aquacultural waste for use in soilless growth systems

Water Sci Technol. 2020 Jan;81(1):81-90. doi: 10.2166/wst.2020.079.

Abstract

The aim of this work was to develop a method that allows the recovery of nutrients from aquaculture sludge, not only to alleviate the disposal problem, but also to address the future scarcity of non-renewable fertilizers. This method includes two steps: Nutrient mobilization using aerobic digestion followed by solids precipitation using chitosan as the flocculant. The aerobic digestion experiments were conducted in aerated batch reactors, while a jar test apparatus was used to assess the capacity of chitosan to remove total suspended solids (TSS) and turbidity. During aerobic digestion, the concentration of soluble N (sum of NH4-N, NO2-N, NO3-N) increased from 181 mg/L at the start to 890 mg/L after three weeks, and to 903 mg/L after four weeks and solids removal by chitosan flocculation. The corresponding concentrations for soluble P were 8.2 mg/L at start, 110 mg/L after three weeks of aerobic digestion, and 160 mg/L after four weeks of aerobic digestion and chitosan flocculation. Other macronutrients (K, Ca, Mg, S) and micronutrients (Fe, Mn, Zn, B, Cu, Mo) were mobilized to concentrations close to or higher than levels recommended for hydroponic growth of vegetables. Chitosan flocculation and precipitation using a dose of 15 mg/L resulted in a reduction of the turbidity by 96% from 156 to 6.5 FNU. After chitosan precipitation, 80% of the sludge could be reclaimed as a nutrient-rich clear phase, low in TSS and turbidity.

MeSH terms

  • Aquaculture
  • Flocculation
  • Nutrients
  • Sewage*
  • Waste Disposal, Fluid*

Substances

  • Sewage