Locally advanced non-small cell lung cancer is optimally managed with chemotherapy and thoracic irradiation, although the most appropriate strategy is not yet defined. In this phase I trial, we use two 21-day cycles of induction chemotherapy with paclitaxel (Taxol; Bristol-Myers Squibb Company, Princeton, NJ) (225 mg/m2 over 3 hours) and carboplatin (area under the concentration-time curve = 6) followed by concurrent weekly paclitaxel (45 mg/m2/wk x 6) and carboplatin (area under the concentration-time curve = 2/wk x 6) and thoracic irradiation. Patients undergo three-dimensional treatment planning (conformal radiotherapy) to define the cancer target volume precisely. The phase I question being addressed in this study is the maximum tolerated radiation dose given concurrently with low-dose paclitaxel and carboplatin. The initial radiation dose is 60 Gy, with dose escalations to 66 Gy, 70 Gy, and 74 Gy being planned. Ten patients have been entered thus far (eight men and two women). Their median age is 67 years (range, 59 to 78 years), and none of the patients has had greater than 5% pretreatment weight loss. Seven of 10 are evaluable for response to induction carboplatin and paclitaxel, with a response rate of 57% (three partial responses and one minor response). Three patients had stable disease and none of the patients had evidence of progressive disease during induction chemotherapy. Three patients have completed all treatment at 60 Gy and one has completed all treatment at 66 Gy. Three of the four patients have had partial responses (75%), with the remaining patient having stable disease. Toxicity in the concurrent chemoradiotherapy portion of the trial thus far has consisted of grade 3 neutropenia in one patient and grade 4 lymphocytopenia in all four patients. No grade 3 or 4 nonhematologic toxicity has been seen. The trial data are not yet mature enough to report on survival. Accrual and treatment is continuing at the 66 Gy radiation dose level.