An analysis of degradation in low-cost particulate matter sensors

Priyanka deSouza; Karoline Barkjohn; Andrea Clements; Jenny Lee; Ralph Kahn; Ben Crawford; Patrick Kinney

doi:10.1039/d2ea00142j

An analysis of degradation in low-cost particulate matter sensors

Environ Sci Atmos. 2023 Feb 3:3:521-536. doi: 10.1039/d2ea00142j.

Authors

Priyanka deSouza^{1

2}, Karoline Barkjohn³, Andrea Clements³, Jenny Lee⁴, Ralph Kahn⁵, Ben Crawford⁶, Patrick Kinney⁷

Affiliations

¹ Department of Urban and Regional Planning, University of Colorado Denver, Denver CO, 80202, USA.
² CU Population Center, University of Colorado Boulder, Boulder CO, 80302, USA.
³ Office of Research and Development, US Environmental Protection Agency, 109 T.W. Alexander Drive, Research Triangle Park, NC 27711, USA.
⁴ Department of Biostatistics, Harvard T.H. Chan School of Public Health, Boston, MA 02115, USA.
⁵ NASA Goddard Space Flight Center, Greenbelt, MD, 20771, USA.
⁶ Department of Geography and Environmental Sciences, University of Colorado Denver, 80202, USA.
⁷ Boston University School of Public Health, Boston, MA, 02118 USA.

Abstract

Low-cost sensors (LCS) are increasingly being used to measure fine particulate matter (PM_2.5) concentrations in cities around the world. One of the most commonly deployed LCS is the PurpleAir with ~ 15,000 sensors deployed in the United States, alone. PurpleAir measurements are widely used by the public to evaluate PM_2.5 levels in their neighborhoods. PurpleAir measurements are also increasingly being integrated into models by researchers to develop large-scale estimates of PM_2.5. However, the change in sensor performance over time has not been well studied. It is important to understand the lifespan of these sensors to determine when they should be serviced or replaced, and when measurements from these devices should or should not be used for various applications. This paper fills this gap by leveraging the fact that: (1) Each PurpleAir sensor is comprised of two identical sensors and the divergence between their measurements can be observed, and (2) There are numerous PurpleAir sensors within 50 meters of regulatory monitors allowing for the comparison of measurements between these instruments. We propose empirically derived degradation outcomes for the PurpleAir sensors and evaluate how these outcomes change over time. On average, we find that the number of 'flagged' measurements, where the two sensors within each PurpleAir sensor disagree, increases with time to ~ 4% after 4 years of operation. Approximately 2 percent of all PurpleAir sensors were permanently degraded. The largest fraction of permanently degraded PurpleAir sensors appeared to be in the hot and humid climate zone, suggesting that sensors in these locations may need to be replaced more frequently. We also find that the bias of PurpleAir sensors, or the difference between corrected PM_2.5 levels and the corresponding reference measurements, changed over time by -0.12 μg/m³(95% CI: -0.13 μg/m³, -0.10 μg/m³) per year. The average bias increases dramatically after 3.5 years. Further, climate zone is a significant modifier of the association between degradation outcomes and time.

Keywords: Degradation; Low-cost sensors; PM2.5; PurpleAir.

Grants and funding

EPA999999/ImEPA/Intramural EPA/United States