The extent of chlorine inactivation and sublethal injury of stationary-phase (STAT) and long-term survival-phase (LTS) cells of Shiga toxin-producing Escherichia coli (STEC) in vitro and in a lettuce postharvest wash model was investigated. Four STEC strains were cultured in tryptic soy broth supplemented with 0.6% (w/v) yeast extract (TSBYE; 35°C) for 24 h and 21 d to obtain STAT and LTS cells, respectively. Minimum bactericidal concentration (MBC) and dose-response assays were performed to determine chlorine's antibacterial efficacy against STAT and LTS cells. Chlorine solutions (pH 6.5) and romaine lettuce were each inoculated with STAT and LTS cells to obtain initial populations of ∼7.8 log colony-forming units (CFU)/mL. Survivors in chlorine solutions were determined after 30 s. Inoculated lettuce samples were held at 22°C ± 1°C for 2 h or 20 h and then exposed to chlorine (10-40 ppm) for 60 s. Survivors were enumerated on nonselective and selective agar media following incubation (35°C, 48 h). The MBC for STAT and LTS cells was 0.04 and 0.08 ppm, respectively. Following exposure (30 s) to chlorine at 2.5, 5.0, and 10 ppm, STAT cells were reduced to <1.0 log CFU/mL, whereas LTS survivors were at 5.10 (2.5 ppm), 3.71 (5.0 ppm), and 2.55 (10 ppm) log CFU/mL. At 20 and 40 ppm chlorine, greater log CFU reductions of STAT cells (1.64 and 1.85) were observed compared with LTS cells (0.94 and 0.83) after 2 h of cell contact with lettuce (p < 0.05), but not after 20 h. Sublethal injury in STEC after chlorine (40 ppm) treatment was lower in LTS compared with STAT survivors (p < 0.05). Compared with STAT cells, LTS cells of STEC seem to have higher chlorine tolerance as planktonic cells and as attached cells depending on cell contact time on lettuce. In addition, a higher percentage of LTS cells, compared with STAT cells, survive in a noninjured state after chlorine (40 ppm) treatment of lettuce.
Keywords: Escherichia coli; chlorination; lettuce; long-term-survival; sub-lethal injury.