An effective and pain-free killing method is required to achieve the goal of euthanasia, a "good death". Overdose of sodium pentobarbital (PB) by intraperitoneal (IP) injection is a widely accepted technique in laboratory rats, but questions remain regarding pain associated with administration. As PB rapidly causes sedation and loss of consciousness, most studies have relied on indirect evidence of pain. The objective of this study was to assess pain associated with IP PB using an appropriate vehicle control. Adult male and female Sprague Dawley (SD) and female Wistar rats (N = 84) were block randomised by sex and strain to receive one of three treatments: 1) 800 mg/kg PB (pH 11), 2) saline or 3) vehicle controls (pH 11 or 12.5). Behavior (Rat Grimace Scale (RGS), writhing, back arching) was evaluated at baseline, before loss of righting reflex (LORR, PB group), and at 80s, 151s and 10 min post-injection (PI; saline and vehicle control groups). In the PB group, mean time to LORR was 78 ± 7.9 seconds. In the vehicle control groups, RGS scores were increased at 151s PI (SD: p = 0.0002, 95%CI 0.73 to 0.20) from baseline, as was relative frequency of writhing (SD: p < 0.0001; Wistar; p = 0.0004). RGS scores remained elevated 10 mins PI (SD: p = 0.0005, 95%CI 0.71 to 0.18; Wistar: p = 0.0234, 95%CI 0.91 to 0.07) but the relative frequency of writhing did not (p > 0.999). The RGS scores and the relative frequency of writhing remained low in the PB and saline groups (p > 0.05). These results show that, vehicle controls for IP PB result in signs associated with pain, pain may not be experienced following IP PB when LORR occurs quickly, and that the effects of PB limit behavioral pain assessments.