Olive oil extraction generates olive cake (OC) that could be used in ruminant feeding. However, the chemical composition of OC is affected by multiple factors, being therefore highly variable. The objective of this study was to analyse the influence of storage time and further processing: crude, exhausted (subjected to a second oil extraction) and cyclone (obtained from a cyclone separator) on nutritive value of OC samples. Twelve samples (six crude and six exhausted) were obtained monthly from the same pond from 1 to 6 storage months, and nine samples (three crude, three exhausted and three cyclone) were obtained monthly from a different pond from 6 to 9 months storage. Chemical composition was analysed, and OC samples were fermented in vitro with sheep rumen fluid. Increasing storage time up to 6 months decreased sugars and total soluble polyphenols content but increased fibre content in OC. Dry matter effective degradability (DMED) decreased linearly (p < 0.001) by 35.9 and 45.5% as storage time augmented from 1 to 6 months for crude and exhausted OC, respectively. Crude OC had lower DMED values than exhausted OC (averaged values 0.255 and 0.294 g/g, respectively). Both potential production and rate of gas production were lower (p ≤ 0.018) in crude compared with exhausted OC, which was attributed to the high fat content of crude OC (≥86 g/kg dry matter). For samples stored longer than 6 months, cyclone had greater (p < 0.05) DMED than crude and exhausted OC (averaged values 0.207, 0.164 and 0.164 g/g, respectively). The results indicate that ruminal degradability of OC is reduced with advancing storage time, but only subtle changes were observed during the first two months. Cyclone showed greater degradability than crude and exhausted OC, but differences between crude and exhausted OC became negligible after five storage months.
Keywords: crude olive cake; exhausted olive cake; gas production; in vitro ruminal fermentation; storage time.
© 2019 Blackwell Verlag GmbH.