Biorefining of rice straw by sequential fermentation and anaerobic digestion for bioethanol and/or biomethane production: Comparison of structural properties and energy output

Mahdy Elsayed; Abd El-Fatah Abomohra; Ping Ai; Dianlong Wang; Hamed M El-Mashad; Yanlin Zhang

doi:10.1016/j.biortech.2018.07.130

Biorefining of rice straw by sequential fermentation and anaerobic digestion for bioethanol and/or biomethane production: Comparison of structural properties and energy output

Bioresour Technol. 2018 Nov:268:183-189. doi: 10.1016/j.biortech.2018.07.130. Epub 2018 Jul 29.

Authors

Mahdy Elsayed¹, Abd El-Fatah Abomohra², Ping Ai³, Dianlong Wang⁴, Hamed M El-Mashad⁵, Yanlin Zhang⁶

Affiliations

¹ College of Engineering, Huazhong Agricultural University, 430070 Wuhan, China; Department of Agricultural Engineering, Faculty of Agriculture, Cairo University, 12613 Giza, Egypt.
² School of Energy and Power Engineering, Jiangsu University, 212013 Jiangsu, China; Botany Department, Faculty of Science, Tanta University, 31527 Tanta, Egypt.
³ College of Engineering, Huazhong Agricultural University, 430070 Wuhan, China. Electronic address: aiping@mail.hzau.edu.cn.
⁴ School of Life Science and Food Engineering, Huaiyin Institute of Technology, Huaian, China.
⁵ Department of Agricultural Engineering, Mansoura University, El-Mansoura, Egypt.
⁶ College of Engineering, Huazhong Agricultural University, 430070 Wuhan, China.

PMID: 30077878
DOI: 10.1016/j.biortech.2018.07.130

Abstract

Three routes; namely R1 representing direct anaerobic digestion (AD), R2 representing enzymatic hydrolysis followed by fermentation, distillation, then AD, and R3 representing AD of fermentation broth without distillation; of alkali pretreated rice straw were investigated. Results showed that sequential fermentation and AD effectively enhanced fibers degradation with significant changes in the composition. Fermentation through R2 resulted in ethanol yield of 87.4 g kg^-1 dry straw. Maximum biogas yields of 286.9, 233.3 and 372.4 L kg^-1 VS were recorded by AD for R1, R2 and R3 after reaching the steady state at 36, 24 and 33 days, respectively. However, biogas produced through R3 showed the highest significant biomethane content (79.3%) which represented 15 and 8% higher than that of R1 and R2, respectively. Therefore, the highest bioenergy output and energy conversion efficiency of 10.58 GJ ton^-1 and 75.6%, respectively, were obtained through R3 demonstrating the positive effect of fermentation prior to AD.

Keywords: Anaerobic digestion; Bioenergy; Biorefinery; Fermentation; Rice straw.

MeSH terms

Biofuels*
Ethanol
Fermentation*
Hydrolysis
Oryza*

Substances

Biofuels
Ethanol