The relationship between serum minerals and stress and(or) disease has not been fully evaluated in beef cattle. Two trials were conducted to determine the changes in serum Cu and Zn during market-transit stress and(or) disease. Two additional trials were conducted to determine the changes in serum Cu and Zn after inoculation with infectious bovine rhinotracheitis virus (IBRV), with one of the trials determining the changes in serum Ca and P. Trials 1 (n = 80) and 2 (n = 100) utilized calves that were handled through a normal market-transit system and transported 1,967 km to the feedlot. Trials 3 (n = 37) and 4 (n = 8) used calves that were sero-negative to IBRV and then challenged with 2.7 x 10(5) plaque-forming units of the virus. Serum samples were collected at specified intervals and serum minerals were measured for each trial. Serum Zn for morbid or IBRV-challenged calves was decreased by 34, 57, 29 and 15% (P less than .05) for the four trials, respectively, at peak morbidity. Serum Cu of morbid or IBRV-challenged calves increased 5, 15, 40 and 33% for the four trials, respectively, at peak morbidity. Feed intakes were lower during morbidity for market-transit trials and after IBRV inoculation. Lower feed intake could partially explain the decrease in serum Zn; however, when feed intake was held constant, serum Zn concentration still decreased. Serum Zn decreased and serum Cu increased during market-transit morbidity or after IBRV.