Enhancing chemical phosphorus precipitation from tapioca starch anaerobic digestion effluent in a modified pilot-scale fluidized bed reactor

Environ Res. 2023 Aug 15;231(Pt 3):116277. doi: 10.1016/j.envres.2023.116277. Epub 2023 May 31.

Abstract

This study aimed to evaluate the possibility of P precipitation as struvite from real anaerobic digestion (AD) effluent of tapioca starch processing. The results showed that at a pH of 9, and without Mg:P molar adjustment, P recovery was at 85%. The percentage of P recovery was increased to 90% and P contained in precipitates was at 11.80-14.70 wt% P, which is higher than commercial single superphosphate fertilizer (SSP, 18-22 wt% P2O5). This was achieved by controlling mixing at 200-400 rpm and upflow velocity at 50-200 cm min-1 inside a fluidized bed reactor (FBR). Based on SEM-EDX, powder XRD, phase identification by profile matching, and FT-IR analysis, the results demonstrated that recovered precipitates formed struvite predominantly. In addition, results of the woodchip ash additions and the one-way ANOVA based-RSM analysis revealed that mixing, the solution pH, and the woodchip ash intensely affected P recovery with the optimum condition found at 400 rpm, pH9, 4 g L-1, respectively. Ash addition enhanced P recovery efficiency but decreased the product's purity. Total costs of P recovery varied considerably from 0.28 to 7.82 USD∙(kg P)-1 depending on chemical consumption and %P content in recovered products. Moreover, the total cost was reduced by 57% from 7.82 USD∙(kg P)-1 (profit margin: -4.30 to -2.82) by a single mixing operation to 3.35 USD∙(kg P)-1 (profit margin: +0.17 to +1.65) employing coupling effect of mixing and Vup. The results indicate that P recovery from tapioca starch AD effluent not only provides a good-quality alternative slow-release P fertilizer, but also helps to curtail environmental problems due to excessive P and nitrogen discharge. These findings also demonstrate the ways of recovering nutrients from an abundant renewable resource that are relevant to simultaneous waste utilization during pollution controls.

Keywords: Nutrient recovery; RSM; Struvite; Waste utilization; Wood ash.

Publication types

  • Research Support, Non-U.S. Gov't

MeSH terms

  • Anaerobiosis
  • Fertilizers
  • Magnesium Compounds
  • Manihot*
  • Phosphates
  • Phosphorus*
  • Spectroscopy, Fourier Transform Infrared
  • Starch
  • Struvite
  • Waste Disposal, Fluid* / methods

Substances

  • Fertilizers
  • Magnesium Compounds
  • Phosphates
  • Phosphorus
  • Starch
  • Struvite