Cheese made from microfiltration (MF) retentate may suffer from textural defects due to a high Ca concentration. The reduction of colloidal minerals by the acidification of milk before MF at pH below 6.0 has been well documented in the literature. This process, however, creates less valuable side streams to the MF process and induces changes in the casein micelles that negatively affect their coagulation properties. The objective of this study was to determine whether a minor reduction in pH by using different acidifiers in the diafiltration (DF) water could induce changes in composition and renneting properties of the MF retentate. A 2-stage filtration process was used, with the first designed to increase the casein concentration to 8% and the second to slightly reduce the casein concentrate by 0.1 pH unit by DF, without influencing the total protein concentration. Four acidifying agents were tested during DF: lactic acid, hydrochloric acid, citric acid, and carbon dioxide. Diafiltration with water was used as a reference. At the start of DF, the retentates of acid DF had a slightly reduced pH, with an average of 0.09, whereas the pH of the reference retentate increased by an average of 0.07 unit. The reference retentate regained its starting pH by the end of DF. The carbonated retentate gradually increased in pH during processing, whereas the pH of the lactic, hydrochloric, and citric acid retentates remained constant. The permeate from the lactic acid and carbonated treatments had a reduced whey protein content compared with the reference. The total P and inorganic phosphate were lowered in the retentate by using carbonation. The total amount of Mg and Na were lowered in the retentate by using citric acid. The ionic Ca content in the retentate increased with use of lactic or hydrochloric acid. The type of acidifier used reduced the rennet clotting time. Combined acidified diafiltration with a slight reduction affects the permeate composition and improves the retentate clotting time despite the minimal mineral modification.
Keywords: acidifying agent; casein concentrate; coagulation; composition; diafiltration.
The Authors. Published by Elsevier Inc. and Fass Inc. on behalf of the American Dairy Science Association®. This is an open access article under the CC BY-NC-ND license (http://creativecommons.org/licenses/by-nc-nd/4.0/).