Many insect-pests have developed resistances to pesticides. Therefore, there is always a need for new plant protection substances. For example the physically active insecticide diatomaceous earth (DE) gained much attention as an alternative insecticide in stored products. DE is a naturally occurring silica, which acts by destroying the insect's cuticle by absorbing the protective wax layer. This results in body water loss and ultimately the insect's death by desiccation. The silica-based materials tested were the commercial DE product Fossil Shield 90.0s, Advasan, and a formulation newly developed by the Urban Horticultural Department at Humboldt University, called Al-06. The trials were performed in small covered plastic boxes. Test substances were either dusted onto the surface of the boxes (E. vigintioctopunctata, S. litura) or mixed into rice medium (S. oryzae). The mortality was observed after 1, 2, 4, 7, 14, and 28 days. Untreated insects served as control. The first test series showed that some AL-06-formulations and FS90.0s were very effective against adults of S. oryzae and S. litura and larvae of E. vigintioctopunctata. For adult Epilachna beetles, we could not detect any differences between the treatments. The highest mortality rate in S. oryzae trials occurred with FS90.0s (100%) after 21 days. The same efficiency was achieved after 2 days with some AL-06 formulations against S. litura and E. vigintioctopunctata. The results of this study indicate that silica dusts can effectively control insect pests from different orders. At higher dosages, all materials resulted in higher insect mortality rates. It was also found that some substances did not perform well under higher rel. humidity; therefore, the conclusion was drawn that hydrophilic substances saturate with water from the surrounding air and lose their insecticidal efficacy. Earlier studies have proven that particles with a larger surface area are more effective than particles with smaller surfaces. As a result, the most effective substances in the field trials were the ones containing the small particles, since there is a larger surface area available to interact with the insects' cuticles. Further studies will be conducted to analyse the relevance of water saturation of substances in order to examine their effectiveness under greenhouse conditions. Greenhouse experiments are generally considered to study practicability of silica dusts in horticulture. Perhaps the silica dusts will show phytotoxic side effects.